郑利云,曹发和,刘文娟,陈安娜,廖晓宁,张鉴清.Q235钢在模拟自然环境下失效行为的电化学研究[J].装备环境工程,2011,8(4):8-15. ZHENG Li-yun,CAO Fa-he,LIU Wen-juan,CHEN An-na,LIAO Xiao-ning,ZHANG Jian-qing.Corrosion Behavior of Q235 in Simulated Natural Environment by Electrochemical Technology[J].Equipment Environmental Engineering,2011,8(4):8-15. |
Q235钢在模拟自然环境下失效行为的电化学研究 |
Corrosion Behavior of Q235 in Simulated Natural Environment by Electrochemical Technology |
投稿时间:2011-02-10 修订日期:2011-08-15 |
DOI: |
中文关键词: 薄液膜 EIS 大气腐蚀 阴极极化曲线 锈层 |
英文关键词:thin electrolyte layer EIS atmospheric corrosion cathodic polarization curve rust layer |
基金项目:国家自然科学基金 (50801056); 浙江省自然科学基金 (Y4110074); 国家科技基础条件平台项目 (2005DKA10400-Z20) |
|
|
摘要点击次数: |
全文下载次数: |
中文摘要: |
采用电化学阻抗谱(EIS)和阴极极化曲线研究了Q235钢在薄液膜条件下的大气腐蚀过程, 探讨了液膜厚度、 Cl-和腐蚀产物对Q235钢失效过程的影响。结果表明液膜厚度会影响O2的扩散过程, 并进一步影响腐蚀速率; Cl-环境下, Q235 钢腐蚀产物分成 2 层, 外层为多孔疏松层, 内层主要为α-FeOOH 和γ-FeOOH组成的锈层, 同时本体溶液中腐蚀产物仅为1层且疏松; 薄液膜下腐蚀速率较本体溶液明显增加, 当液膜厚度为202 μm时, 在阴极过程和腐蚀产物的共同控制下, 腐蚀速率最大, 局部腐蚀孔最深。 |
英文摘要: |
The atmospheric corrosion process of Q235 steel under thin electrolyte layer (TEL) was investigated by electrochemical impedance spectroscopy (EIS) and cathodic polarization. The influence of the thickness of TEL, chloride ions, and corrosion production on the degradation process of Q235 steel was discussed. The results indicated that the thickness of TEL affect the diffusion process of O2, which further influence the corrosion rate. The effect of TEL to the two-layer rust under Cl- containing environment was analyzed. The rust layer is composed of outer layer which is porous and loose and an inner layer containing α-FeOOH and γ-FeOOH. However the rust layer was only one layer in bulk solution which was rather porous. The corrosion rate of Q235 steel under TEL is higher than that in bulk solution, which is controlled by cathodic process and corrosion product. The corrosion rate is maximum under 202 μm TEL, while localized pit is deepest. |
查看全文 查看/发表评论 下载PDF阅读器 |
关闭 |